都知道
水泥自動攪拌車是運輸混凝土的專用車輛，我們先看看水泥自動攪拌車的主要使用特點，掌握以下幾點。
We all know that cement automatic mixer is a special vehicle for transporting concrete. Let's first look at the main features of cement automatic mixer and master the following points.
1、攪拌車液壓傳動系統液壓油的壓力、油量、油質、油溫應達到規定要求，無滲漏現象
1. The hydraulic oil pressure, oil quantity, oil quality and oil temperature of the hydraulic transmission system of the mixing truck shall meet the specified requirements without leakage
2、攪拌運輸中，裝載混凝土量不能超過允許裝載質量。
2. During mixing and transportation, the amount of concrete loaded shall not exceed the allowable loading mass.
3、攪拌車在露天停放時，裝料前應先將攪拌筒反轉，使筒內的積水和雜物排出。裝料前，好先向筒內加水，使進料流暢，防止粘料。
3. When the mixing truck is parked in the open air, the mixing drum shall be reversed before loading to discharge the accumulated water and sundries in the drum. Before loading, add water into the cylinder to make the feeding smooth and prevent sticking.
4、攪拌車行駛中，接長的卸料槽必須翻轉后固定在卸槽上，再轉至與車身垂直部位，用銷軸與機架固定，防止由于不固定而引起擺動，打傷行人或影響車輛運行。
4. During the driving of the mixer truck, the extended discharge chute must be turned over and fixed on the discharge chute, then turned to the vertical position with the body, and fixed with the pin shaft and the frame to prevent the swing caused by unfixed, hurting pedestrians or affecting the vehicle operation.
5、攪拌車通過橋、洞、庫等設施時，應注意通過高度及寬度，以免發生碰撞事故。特別需要注意的是現在四軸罐車的長度很長，在通過橋洞高度接近極，長長的車身是下圓弧路面的一道弦，能通過的高度會降低。
5. When the mixing truck passes through the bridge, tunnel, warehouse and other facilities, pay attention to the height and width to avoid collision accidents. It is particularly important to note that the length of the four-axle tank car is very long now. When the height of passing through the bridge is close to the limit, the long body is a chord of the lower arc road, and the height of passing through will be reduced.
6、攪拌裝置連續運轉時間不超過8h。
6. The continuous operation time of the mixing device shall not exceed 8h.
7、攪拌車運送混凝土的時間不得超過攪拌車規定的時間，以免影響混凝土質量。
7. The mixing truck shall not transport concrete more than the time specified by the mixing truck to avoid affecting the concrete quality.
8、運送混凝土途中，攪拌筒不得停轉，以防混凝土產生初凝及離析現象。
8. During the transportation of concrete, the mixing drum shall not be stopped to prevent the initial setting and segregation of concrete.
9、攪拌筒由正轉變為反轉時，必須先將操縱手柄放置中間位置，待攪拌筒停轉后，再將操縱手柄放置反轉位置。
9. When the mixing drum changes from positive to reverse, the operating handle must be placed in the middle position first, and then placed in the reverse position after the mixing drum stops rotating.
10、水箱的水量要盡量保持裝滿，以防急用。冬季停車時，要將水箱和供水系統的水放凈。
10. The water tank should be kept as full as possible in case of emergency. When parking in winter, drain the water in the water tank and water supply system.
The slow rotation of the mixing drum during concrete transportation can effectively prevent the initial setting and segregation of concrete, thus ensuring the delivery quality of concrete. Come to our website for more relevant content http://www.top2010.cn Ask!
上一篇：自動攪拌車每天清洗的必要性和正確的清洗方法
下一篇：自動攪拌車的拌筒在運轉時注意什么？
