水泥自上料攪拌車進工地時要注意多方面觀察，比如：一般工地道路簡易，路基比較松軟，靠近路邊，容易被壓塌方了，導致車輛側翻。工地一般工況復雜，倒車時下車?yán)@車一周，查看倒車路線，注意躲避障礙物和坑洼，清理遇到的鋼筋釘子。別總是把頭伸出窗外，要看著兩邊后視鏡一起兼顧，實在不確定就停車看清楚再倒。用一檔起步倒車，緩慢而勻速的行駛，好多路面是挖掘機剛剛鋪的比較軟，車容易陷入。
When the cement self loading mixer truck enters the construction site, attention should be paid to multiple aspects of observation. For example, in general, the road on the construction site is simple, the roadbed is relatively soft, and close to the roadside, it is easy to be crushed, causing the vehicle to roll over. The general working conditions of the construction site are complex. When reversing, get off the car and take a detour around the car. Check the reversing route, pay attention to avoiding obstacles and potholes, and clean up any steel nails encountered. Don't always stick your head out of the window. Look at both rearview mirrors and consider them together. If you're unsure, stop and look clearly before reversing. Starting from first gear and reversing at a slow and uniform speed, many roads have just been paved with soft excavators, making it easy for the car to get stuck.
裝料時注意清潔：
Pay attention to cleanliness during loading:
1、裝料前先將攪拌筒反轉
1. Reverse the mixing drum before loading
水泥自上料攪拌車一般露天停放，裝料前先將罐里的積水和樹葉之類的雜物排出，以免影響混凝土質量。
The cement self loading mixer truck is generally parked outdoors. Before loading, the accumulated water and debris such as leaves in the tank should be discharged to avoid affecting the quality of the concrete.
2、裝完料要記得沖洗進料斗
2. Remember to flush the feed hopper after loading
洗完后要關掉水箱進氣口，打開水箱排氣口排掉氣體，因?yàn)闅鈮合拢苓B接不好的地方，容易滲水，影響其他車輛的安全。再次檢查輪胎是否卡有石子鐵釘?shù)入s物，使用工具及時清理，因?yàn)橥＼嚂r(shí)輪胎與地面接觸的地方是檢查不到的。
After washing, it is necessary to turn off the air inlet of the water tank and open the air outlet of the water tank to exhaust the gas. This is because under pressure, areas where the water pipe is not properly connected can easily leak water, affecting the safety of other vehicles. Check the tires again for debris such as stones and nails, and use tools to clean them in a timely manner, as the area where the tires come into contact with the ground during parking cannot be detected.
出料時須當心：
Be careful when discharging:
1、卸料前讓攪拌罐全速運轉幾分鐘
1. Allow the mixing tank to run at full speed for a few minutes before unloading
高速轉動讓混凝土充分?jǐn)嚢瑁乐鼓蹋梢约右恍┧矫娉隽稀?/div>
High speed rotation allows the concrete to be fully mixed to prevent solidification, and some water can be added to discharge the material.
2、出料前先把出料斗溜槽打濕
2. Wet the chute of the discharge hopper before discharging
盡量將車停在平地上出料，出料前先把出料溜槽打濕，防止混凝土粘結在溜槽，容易清洗。
Try to park the vehicle on a flat surface for discharge, and wet the discharge chute before discharge to prevent concrete from sticking to the chute, which is easy to clean.
3、卸料不要大意
3. Don't be careless when unloading
出料時全程看著，免得放料工亂操作放料操作桿，每次罐子正反轉中間位子時好停一下，保護減速機，托盤。
When discharging, keep an eye on the entire process to prevent the discharge worker from operating the discharge lever recklessly. Every time the can is rotated in the middle position, it is easy to stop and protect the reducer and tray.
4、攪拌罐沖洗干凈
4. Rinse the mixing tank thoroughly
攪拌車一定要仔細的沖洗干凈，多次反復正轉反轉罐體，使水無死角清理，多次加水清洗，保持罐體內部的清潔，無混凝土殘留。
The mixing truck must be carefully washed clean, repeatedly rotating and reversing the tank body to ensure that there are no dead corners in the water for cleaning, and adding water multiple times for cleaning to maintain the cleanliness of the tank body and no concrete residue.
以上就是小編總結的水泥自上料攪拌車使用時的注意事項，請大家在使用時遵循規章制度，安全生產。更多相關事項就來我們網站
http://www.top2010.cn咨詢吧！
The above is the summary by the editor of the precautions for using cement self loading mixer trucks. Please follow the rules and regulations when using them, and ensure safe production. For more related matters, come to our website http://www.top2010.cn Consult!
上一篇：水泥自動攪拌車的車燈要知道什么？
下一篇：自動攪拌車空氣濾清器堵塞是在怎么回事？
